Comment by richx
11 hours ago
I am affacted by this as well: the rear knuckle uniball bearing was broken after 3 years (Achsschenkel). Many MY here in Europe have this issue, due to bad parts or too hard suspension.
But there are two other things that make it a bit unfair for Tesla in comparison to other brands:
Often the cars fail official inspections because of rotten breaks - this happens when your drive carefully and the Tesla is using regenerative breaking instead of the real breaks. Simple solution is to force breaking from time to time (I.e. breaking in neutral). Another aspect is, that all the other brands have a mandatory inspection from the manufacturer before the cars will be tested by the independent check. This avoids that they will fail it, because the car will be repaired before it is checked by the independent inspection. This is not mandatory for Teslas.
> Often the cars fail official inspections because of rotten br[e]ak[e]s - this happens when your drive carefully and the Tesla is using regenerative breaking instead of the real br[e]ak[e]s.
That's something that they should have taken into consideration when designing the car.
> that all the other brands have a mandatory inspection from the manufacturer before the cars will be tested by the independent check.
I'm in Europe. Never heard of mandatory inspection before independent checks. How would that even work, or be enforced.
Service intervals. Other OEMs will prompt a service interval at X thousand miles/km to go pop in and have it looked at by a dealer, probably swap out your cabin air filter, upsell you on some new wiper blades, etc.
ICE vehicles would normally catch these issues sooner because you'd be pulling in a lot more often for oil changes (and a quick mechanical inspection is typically a courtesy at that time).
I think the break rusting issue can be fixed in software.
>Often the cars fail official inspections because of rotten breaks - this happens when your drive carefully and the Tesla is using regenerative breaking
Huh? Every EV uses recuperative braking, how is this special to Tesla?
The Teslas have far stronger regen than other brands. Have you ever wondered why Tesla's Long Range models have 500 horsepower? It's not for increased acceleration power, it's for increased braking power. Far less energy is wasted on the friction brakes in a Tesla.
> Huh? Every EV uses recuperative braking, how is this special to Tesla?
It‘s not. But there are some newer EVs (e.g. Mercedes and VW) that track brake usage and will periodically switch to using the disk brakes when there‘s danger of corrosion.
German TUV thinks Teslas are horrible because apparently nobody is servicing their brakes on a regular enough interval so every time Teslas get pulled in for their 2 year inspections after 3 years of ownership they keep failing out on brakes and suspension, but VWs are the pinnacle of perfection because they slam 10K service intervals in your face.
(Of note: I drive a hybrid vehicle, and over 125,000+ miles of ownership I have replaced my front brakes once and my rear brakes three times now in five years.)
I'm at 125000 on my Long Range Model 3. I plugged a tire last month and photographed brake caliper - like new. I could not believe it. I can upload a photo if you'd like.
1 reply →